High Efficiency Boiling Dryer Five System and Characteristics Introduction

Efficient boiling dryer five systems:
1, the host system: filter room: with filter powder body, expansion room; drying room: cart; base: floating with a drainage mechanism; column: built-in air cable and rope.
2, the air heating system: the cabinet is 304 stainless steel; radiator: steam heating; steam valve: angle seat valve; radiator material: 1Cr18Ni9Ti.
3, air filtration system: early, medium efficiency, sub-efficient filter; screen, non-woven cotton, filter paper.
4, the discharge system: induced draft fan: frequency adjustment air volume; muffler; into the air duct;
5, the control system: button operating system PLC control procedures. A full set of equipment centralized control, the motor current, voltage and temperature are in the electronic control cabinet response and feedback. All low-voltage electrical appliances, pneumatic use of high-quality electrical components.
advantage:
1, the whole structure is compact, simple operation, equipment, no dead ends, easy disassembly and cleaning, contact with the material part of the use of 304 stainless steel or plexiglass production.
2, efficient boiling dryer air volume and temperature can be implemented stepless speed regulation and temperature control, hot and cold air can switch at any time.
3, efficient boiling dryer in the closed container operation, the whole seal is good, no dust flying, improve the operating environment.
4, filter bag with anti-static filter, the device safe operation.
5, drying time is short; feeding interval: the minimum amount of drying only a few grams, the maximum drying up to 200 grams.
6, efficient boiling dryer power supply voltage is 220V 50HZ
Working principle and use
High efficiency boiling dryer is a fluidized dryer. It is the use of hot air and materials in full contact with the water away, so as to achieve a dry dryer, is a dynamic drying equipment. In the outlet with a temperature control probe, can be measured at any time the temperature of the outlet. Will need to dry the material into the hopper, and then use the clamp to the plexiglass tube and Sheng barrels fixed, forming a closed system, open the power switch, fan knob. The cold air enters under negative pressure, then turns on the hot and cold switch to raise the temperature, set the appropriate heating temperature as required, and set a differential value (factory set to 10). If the maximum temperature is set to 70 ℃, when the outlet temperature reaches 70 ℃ will stop heating, less than 60 ℃ will automatically heat. So that the granular material, the powdered material was fluidized like the cycle of boiling, the water quickly evaporated out into the air, through the bag material was blocked down, water, water vapor through the cloth bag away, usually 3-8 minutes later The Stop pouring out material. High efficiency boiling dryer is widely used in pharmaceutical, pesticide, food and other industries in the scientific research units, all kinds of experimental granular or powdery materials, rapid drying. Efficient boiling dryer is ideal for laboratory drying equipment.